Spacewalking astronauts tackle battery, cable work
By MARCIA DUNN
AP Aerospace Writer
CAPE CANAVERAL, Fla. (AP) - Spacewalking astronauts completed battery and cable work outside the International Space Station on Monday despite communication trouble that sometimes made it hard for them to hear.
During the spacewalk, Canadian astronaut David Saint-Jacques reported that U.S. astronaut Anne McClain's voice was faint at times. The problem worsened as their 6 ½-hour excursion drew to a close.
"We know that it's a lot of hard work and a lot of big sighs of relief as soon as this hatch gets closed," McClain said once the pair were inside the air lock.
Within moments, the spacewalkers could barely hear their colleagues over the radio loop. They had to shout and repeat words at times, as did the astronauts on the other side of the hatch.
McClain, meanwhile, reported having a thin layer of moisture inside her helmet. The change to her visor was noticeable in the last 15 minutes of the spacewalk, she noted.
NASA is wary about moisture inside helmets ever since an Italian astronaut almost drowned during a spacewalk nearly six years ago because of a water leak in his suit. McClain insisted she wasn't wet, and that the moisture was minimal. A crewmate later noted perspiration.
Earlier, McClain and Saint-Jacques hustled through their part in battery swap-outs that began last month. It was the third spacewalk in just 2 ½ weeks for the space station crew.
The cable routing took more time, providing a backup power circuit for the station's Canadian-made robot arm and expanding wireless communications. At one point, the spacewalkers had to use a pry bar to loosen a stuck fastener and get behind a protective panel.
The ongoing battery work involved re-installing two old batteries. One of six new lithium-ion batteries did not work, so McClain had to remove an adapter plate she put in.
Last week, flight controllers used the space station's robot arm to remove the failed battery along with an associated charging device. Working remotely, the controllers also installed a spare charging device and one of the old batteries made of nickel hydrogen. The second outdated battery will go in - robotically - later this week.
NASA said it will send up another new battery, although it's uncertain when. Until then, this combination of old and new batteries is expected to work fine, according to managers.
Because of trouble with a trunnion pin, Saint-Jacques could not complete prep work for a future payload platform.
McClain has now logged two spacewalks and Saint-Jacques one. Their six-month mission began in December.
The next spacewalk will be next month by the two Russians on board. Two other Americans round out the six-person crew.
The Associated Press Health and Science Department receives support from the Howard Hughes Medical Institute's Department of Science Education. The AP is solely responsible for all content.
Copyright 2019 The Associated Press. All rights reserved. This material may not be published, broadcast, rewritten or redistributed.